5962-0620705, 5962-0620706,
5962-0620707, 5962-0620708
Data Sheet
November 3, 2011
FN6298.1
±15kV ESD Protected, +5.0V 1Microamp,
250kbps, RS-232 Transmitters/Receivers
The Intersil 5962-062070xQxA devices are 5.0V powered
RS-232 transmitters/receivers which meet ElA/TIA-232 and
V.28/V.24 specifications. Additionally, they provide ±15kV
ESD protection (IEC61000-4-2 Air Gap and MIL-STD 883
Human Body Model) on transmitter outputs and receiver
inputs (RS-232 pins). Targeted applications include
ruggedized portable products and remotely deployed
devices exposed to extreme temperature and humidity
where the low operational and even lower standby, power
consumption is critical. Efficient on-chip charge pumps,
coupled with manual and automatic power-down functions
(except for the 5962-0620707Q2A), reduce the standby
supply current to a 1µA trickle. Small footprint packaging and
the use of small, low value capacitors ensure board space
savings as well. Data rates greater than 250kbps are
guaranteed at worst case load conditions. This family is fully
compatible with 5.0V-only systems.
Specifications for QML devices are controlled by the
Defense Logistics Agency Land and Maritime (DLA). The
SMD numbers listed here must be used when ordering.
Detailed Electrical Specifications for these devices are
contained in SMD 5962-06207. A “hot-link” is provided
on our website for downloading.
Features
• Meets EIA/TIA-232 and V.28/V.24 Specifications at 5V
• Electrically Screened to DLA SMD#5962-06207
• QML Qualified per MIL-PRF-38535 Requirements
• SMD Compliance
• Military Temperature Range
• Latch-up Free
• Hermetic Package
• ESD Protection for RS-232 I/O Pins to ±15kV (IEC61000)
• Guaranteed Mouse Driveability (ICL3243E)
• Requires Single +5.0V ±10% Power Supply
• Receiver Hysteresis for Improved Noise Immunity
• Low Power Automatic Power-down Modes
(Except for ICL3232E) . . . . . . . . . . . . . . . . . . . . . . . . .1µA
• Guaranteed Minimum 250kbps Data Rate
• Manual and Automatic Power-down Features
• Multiple Drivers/Receivers
• On-Chip Voltage Converters Require Only Four External
Capacitors
• Regulated Dual Charge Pumps
Ordering Information
DESC P/N
CONFIGURATION TEMP (°C) PACKAGE
-55 to +125 28 Ld CLCC
-55 to +125 28 Ld CLCC
-55 to +125 20 Ld CLCC
-55 to +125 20 Ld CLCC
5962-0620705Q3A ICL3243E 3D/5R
5962-0620706Q3A ICL3238E 5D/3R
5962-0620707Q2A ICL3232E 2D/2R
5962-0620708Q2A ICL3221E 1D/1R
Applications
• Any Military or High-Rel System Requiring RS-232
Communication Ports
- Battery Powered, Hand-Held, and Portable Equipment
- Ruggedized Handheld GPS, Laptop Computers,
Notebooks, Palmtops
- Industrial Control/Shop Floor Communications
- Field Deployed Sensors/Devices Exposed to Extreme
Temperature/Humidity
- Ruggedized Cellular/Mobile Phones
1
CAUTION: These devices are sensitive to electrostatic discharge; follow proper IC Handling Procedures.
1-888-INTERSIL or 1-888-468-3774
|
Intersil (and design) is a registered trademark of Intersil Americas Inc.
Copyright Intersil Americas Inc. 2006, 2011. All Rights Reserved
All other trademarks mentioned are the property of their respective owners.
5962-0620705, 5962-0620706, 5962-0620707, 5962-0620708
Pinouts
ICL3221E (CLCC)
TOP VIEW
FORCEOFF
ICL3232E (CLCC)
TOP VIEW
GND
18 NC
17 T1
OUT
16 R1
IN
15 R1
OUT
14 T1
IN
9 10 11 12 13
R2
IN
T2
OUT
R2
OUT
T2
IN
NC
VCC
NC
3
C1- 4
C2+ 5
C1+
V+
2
GND
3
C1-
C2+
C2-
V-
NC
4
5
6
7
8
9
R1
IN
2
1
20 19
18 NC
17 GND
16 T1OUT
15 NC
14 FORCEON
VCC
1 20 19
C1+
EN
V+
C2- 6
V- 7
NC 8
10 11 12 13
INVALID
R1
OUT
T1
IN
NC
ICL3243E (CLCC)
TOP VIEW
R
1 IN
VCC
C2+
C
1
+
C2-
V+
ICL3238E (CLCC)
TOP VIEW
VCC
26
25 C1-
24 T1 IN
23 T2 IN
22 T3 IN
21 R1 OUT
20 R2 OUT
19 T4 IN
12
T5 OUT
13
FORCEON
14
FORCEOFF
15
INVALID
16
R1OUTB
17
T5 IN
18
R3 OUT
FN6298.1
November 3, 2011
C2+
C1+
28
C2-
V-
R
2 IN
R
3 IN
R
4 IN
R
5 IN
T
1 OUT
T
2 OUT
T
3 OUT
4
5
6
7
8
9
10
11
12
T
3 IN
3
2
1
28
27
26
25
24
23
22
21
20
19
GND
C1-
FORCEON
FORCEOFF
INVALID
R
2OUTB
R
1 OUT
T1 OUT
T2 OUT
T3 OUT
R1 IN
R2 IN
T4 OUT
R3 IN
5
6
7
8
9
10
11
4
3
2
1
13
T
2 IN
14
T
1 IN
15
R
5 OUT
16
R
4 OUT
17
R
3 OUT
18
R
2 OUT
2
V+
27
V-
5962-0620705, 5962-0620706, 5962-0620707, 5962-0620708
Pin Descriptions
PIN
V
CC
V+
V-
GND
C1+
C1-
C2+
C2-
T
IN
T
OUT
R
IN
R
OUT
R
OUTB
INVALID
EN
FORCEOFF
FORCEON
NOTE:
1. The ICL3238E input pins incorporate positive feedback resistors. Once the input is driven to a valid logic level, the feedback resistor maintains
that logic level until V
CC
is removed. Unused transmitter inputs may be left unconnected by the user.
System power supply input (4.5V to 5.5V).
Internally generated positive transmitter supply.
Internally generated negative transmitter supply.
Ground connection.
External capacitor (voltage doubler) is connected to this lead.
External capacitor (voltage doubler) is connected to this lead.
External capacitor (voltage inverter) is connected to this lead.
External capacitor (voltage inverter) is connected to this lead.
TTL/CMOS compatible transmitter Inputs. (Note 1)
±15kV ESD Protected, RS-232 level (nominally ±5.5V) transmitter outputs.
±15kV ESD Protected, RS-232 compatible receiver inputs.
TTL/CMOS level receiver outputs.
TTL/CMOS level, noninverting, always enabled receiver outputs.
Active low output that indicates if no valid RS-232 levels are present on any receiver input.
Active low receiver enable control.
Active low control to shut down transmitters and on-chip power supply. This overrides any automatic circuitry and FORCEON
(See Tables 1 & 2, Note 1).
Active high input to override automatic power-down circuitry thereby keeping transmitters active. (FORCEOFF must be high,
Note 1).
FUNCTION
TABLE 1. POWER-DOWN LOGIC TRUTH TABLE
RCVR OR
XMTR
EDGE
WITHIN 30
SEC?
ICL3238E
No
No
Yes
Yes
No
No
X
X
H
H
H
H
H
H
L
L
H
H
L
L
L
L
X
X
Active
Active
Active
Active
High-Z
High-Z
High-Z
High-Z
Active
Active
Active
Active
Active
Active
High-Z
High-Z
Active
Active
Active
Active
Active
Active
Active
Active
No
Yes
No
Yes
No
Yes
No
Yes
L
H
L
H
L
H
L
H
Normal Operation (Enhanced
Auto Power-down Disabled)
Normal Operation (Enhanced
Auto Power-down Enabled)
Power-down Due to Enhanced
Auto Power-down Logic
Manual Power-down
RS-232
LEVEL
PRESENT
AT
RECEIVER
INPUT?
FORCEOFF FORCEON TRANSMITTER RECEIVER
INPUT
INPUT
OUTPUTS
OUTPUTS
R
OUTB
OUTPUT
INVALID
OUTPUT
MODE OF OPERATION
3
FN6298.1
November 3, 2011
5962-0620705, 5962-0620706, 5962-0620707, 5962-0620708
TABLE 1. POWER-DOWN LOGIC TRUTH TABLE (Continued)
RCVR OR
XMTR
EDGE
WITHIN 30
SEC?
RS-232
LEVEL
PRESENT
AT
RECEIVER
INPUT?
FORCEOFF FORCEON TRANSMITTER RECEIVER
INPUT
INPUT
OUTPUTS
OUTPUTS
R
OUTB
OUTPUT
INVALID
OUTPUT
MODE OF OPERATION
INVALID DRIVING FORCEON AND FORCEOFF
(EMULATES AUTOMATIC POWER-DOWN)
X
X
NOTE:
2. Input is connected to INVALID Output.
TABLE 2. POWER-DOWN AND ENABLE LOGIC TRUTH TABLE
RS-232
SIGNAL
PRESENT
AT
RECEIVER
INPUT?
ICL3221E
No
No
Yes
Yes
No
No
Yes
Yes
No
No
ICL3243E
No
Yes
No
Yes
No
NOTE:
3. Applies only to the ICL3243E.
H
H
H
L
L
H
L
L
X
X
N.A.
N.A.
N.A.
N.A.
N.A.
Active
Active
High-Z
High-Z
High-Z
Active
Active
Active
High-Z
High-Z
Active
Active
Active
Active
Active
L
H
L
H
L
Normal Operation
(Auto Power-down Disabled)
Normal Operation
(Auto Power-down Enabled)
Power-down Due to Auto Power-down
Logic
Manual Power-down
Manual Power-down
H
H
H
H
H
H
L
L
L
L
H
H
L
L
L
L
X
X
X
X
L
H
L
H
L
H
L
H
L
H
Active
Active
Active
Active
High-Z
High-Z
High-Z
High-Z
High-Z
High-Z
Active
High-Z
Active
High-Z
Active
High-Z
Active
High-Z
Active
High-Z
N.A.
N.A.
N.A.
N.A.
N.A.
N.A.
N.A.
N.A.
N.A.
N.A.
L
L
H
H
L
L
H
H
L
L
Normal Operation
(Auto Power-down Disabled)
Normal Operation
(Auto Power-down Enabled)
Power-down Due to Auto Power-down
Logic
Manual Power-down
Manual Power-down w/Rcvr. Disabled
Manual Power-down
Manual Power-down w/Rcvr. Disabled
Note 2
Note 2
Note 2
Note 2
Active
High-Z
Active
High-Z
Active
Active
Yes
No
H
L
Normal Operation
Forced Auto Power-down
(NOTE 3)
FORCEOFF FORCEON
R
OUTB
EN
TRANSMITTER RECEIVER
INVALID
INPUT
INPUT
INPUT
OUTPUTS
OUTPUTS OUTPUTS OUTPUT
MODE OF OPERATION
4
FN6298.1
November 3, 2011
5962-0620705, 5962-0620706, 5962-0620707, 5962-0620708
Absolute Maximum Ratings
V
CC
to Ground . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . -0.3V to 6V
V+ to Ground . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . -0.3V to 7V
V- to Ground. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . +0.3V to -7V
V+ to V- . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14V
Input Voltages
T
IN
, FORCEOFF, FORCEON, EN . . . . . . . . . . . . . . . -0.3V to 6V
R
IN
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ±25V
Output Voltages
T
OUT
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ±13.2V
R
OUT
, INVALID . . . . . . . . . . . . . . . . . . . . . . . . -0.3V to V
CC
+0.3V
Short Circuit Duration
T
OUT
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Continuous
ESD Rating (Receiver Input and Transmitter Output Pins) . . . ±15kV
Thermal Information
Thermal Resistance (Typical)
θ
JA
(°C/W)
20 Ld CLCC Package . . . . . . . . . . . . . . . . . . . . . . .
90
28 Ld CLCC Package . . . . . . . . . . . . . . . . . . . . . . .
70
Maximum Junction Temperature (Ceramic Package) . . . . 150°C
Maximum Storage Temperature Range . . . . . . . . . . . -65°C to 150°C
Maximum Lead Temperature (Soldering 10s) . . . . . . . . . . . . 300°C
Operating Conditions
Temperature Range
ICL32XXE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . -55°C to 125°C
CAUTION: Stresses above those listed in “Absolute Maximum Ratings” may cause permanent damage to the device. This is a stress only rating and operation of the
device at these or any other conditions above those indicated in the operational sections of this specification is not implied.
Electrical Specifications
ICL3221E, ICL3232E, ICL3243E
Test Conditions: V
CC
= 4.5V to 5.5V, C1 = 0.01
m
F, C2 - C4 = 0.1
m
F; Unless
Otherwise Specified. Typicals are at T
A
= 25°C, V
CC
= 5.0V
TEST CONDITIONS
TEMP
(°C)
MIN
TYP
MAX
UNITS
PARAMETER
DC CHARACTERISTICS
Supply Current, Automatic
Power-down
Supply Current, Power-down
Supply Current, Power-up
All R
IN
Open, FORCEON = GND, FORCEOFF = V
CC
(ICL3221E, ICL3243E Only)
FORCEOFF = GND (Except ICL3232E)
All Outputs Unloaded, FORCEON = FORCEOFF = V
CC
T
IN
, FORCEON, FORCEOFF, EN
T
IN
, FORCEON, FORCEOFF, EN
T
IN
, FORCEON, FORCEOFF, EN
FORCEOFF = GND or EN = V
CC
I
OUT
= 1.6mA
I
OUT
= -1.0mA
Powers Up
Powers Down
I
OUT
= 1.6mA
I
OUT
= -1.0mA
Full
Full
Full
-
-
-
1
1
0.3
10
10
1.8
μA
μA
mA
LOGIC AND TRANSMITTER INPUTS AND RECEIVER OUTPUTS
Input Logic Threshold Low
Input Logic Threshold High
Input Leakage Current
Output Leakage Current
(Except ICL3232E)
Output Voltage Low
Output Voltage High
Full
Full
Full
Full
Full
Full
-
2.2
-
-
-
-
-
±0.01
±0.05
-
0.8
-
±10
±10
0.4
-
V
V
μA
μA
V
V
V
CC
-0.9 V
CC
-0.3
-2.7
-0.3
-
V
CC
-0.9
-25
0.6
-
3
-
-
-
-
AUTOMATIC POWER-DOWN
(ICL3221E, ICL3243E Only, FORCEON = GND, FORCEOFF = V
CC
)
Receiver Input Thresholds to
Enable Transmitters
Receiver Input Thresholds to
Disable Transmitters
INVALID Output Voltage Low
INVALID Output Voltage High
RECEIVER INPUTS
Input Voltage Range
Input Threshold Low
Input Threshold High
Input Resistance
TRANSMITTER OUTPUTS
Output Voltage Swing
Output Resistance
Output Short-Circuit Current
All Transmitter Outputs Loaded with 3kW to Ground
V
CC
= V+ = V- = 0V, Transmitter Output = ±2V
Full
Full
Full
±5.0
300
-
±5.4
10M
±35
-
-
±60
V
Ω
mA
Full
Full
Full
Full
-
1.2
1.5
5
25
-
2.4
7
V
V
V
kΩ
Full
Full
Full
Full
2.7
0.3
0.4
-
V
V
V
V
5
FN6298.1
November 3, 2011
微控制器 MCU
京公网安备 11010802033920号
Copyright © 2005-2026 EEWORLD.com.cn, Inc. All rights reserved
电子工程世界
