Installation and Technical Manual for the
Limitless™ Series WDRR Receiver
50063987
ISSUE 5
WARNING
•
DO NOT USE these products as safety or emergency
stop devices or in any other application where failure of
the product could result in personal injury.
Failure to comply with these instructions could result in
death or serious injury.
PERSONAL INJURY
•
The WDRR must be installed in accordance with the
requirements specified in this document in order to comply
with the specific Country Communication Agency
requirements. (i.e. FCC, IC, ETSI, ACMA, etc.) See
Section 3 as it requires choosing the correct Country Use
Code and thus allowable antenna and/or cable usage.
WARNING
WARNING
Honeywell does not recommend using devices for critical
control applications where there is, or may be, a single point
of failure or where single points of failure may result in an
unsafe condition. It is up to the end-user to weigh the risks
and benefits to determine if the products are appropriate for
the application based on security, safety and performance.
Additionally, it is up to the end-user to ensure that the
control strategy results in a safe operating condition if any
crucial segment of the control solution fails.
Honeywell customers assume full responsibility for learning
and meeting the required Declaration of Conformity,
Regulations, Guidelines, etc. for each country in their
distribution market.
Failure to comply with these instructions could result in
death or serious injury.
•
Pay attention to ESD discharge at dc-in port.
WARNING
WARNING
•
Korean Communication Commission does not allow this
equipment to be used for rescue service.
•
Anatel states that this device works as a secondary
function model. It may not be used as a protection device
against harmful interference. It cannot cause interference
with systems that are running as primary function.
WARNING
CAUTION
* Power to the WDRR should not be applied during
installation of antenna as damage could occur to the
WDRR electronics.
WARNING
•
To satisfy FCC RF exposure requirements for mobile
transmitting devices, a separation distance of 20 cm or
more should be maintained between the antenna of this
device and persons during device operation To ensure
compliance, operation at closer than this distance is not
recommended. The antenna used for this transmission
must not be co-located in conjunction with any other
antenna or transmitter.
Failure to comply with these instructions could result in
death or serious injury.
RF EXPOSURE
CAUTION
* The WDRR receiver offers optimal performance when
paired with Limitless™ inputs that have a firmware
version of 7170 or a greater number (i.e., FW7170 will be
printed on the Limitless™ input label). If the Limitless™
input is paired with older firmware (FW7170 or a lesser
number), the WDRR may exhibit delayed responses
under simultaneous operation.
Sensing and Productivity Solutions
Limitless™
WDRR Receiver
T
ABLE OF
C
ONTENTS
Issue 5
50063987
TABLE OF CONTENTS
............................................................................................................................................................ II
LIST OF FIGURES
.................................................................................................................................................................... VI
LIST OF TABLES
....................................................................................................................................................................... 6
1...................................................................................................................................................................................................... 6
1
DESCRIPTION
.................................................................................................................................................................... 1
1.1
1.2
1.3
1.4
2
2.1
2.2
2.3
2.4
2.5
2.6
2.7
2.8
2.8.1
2.8.2
2.8.3
2.8.4
2.8.5
2.8.6
2.9
2.9.1
2.9.2
3
3.1
3.2
4
5
5.2
5.4
5.5
5.6
6
6.1
6.2
6.3
6.4
6.5
6.6
ii
G
ENERAL
........................................................................................................................................................................ 1
P
RINCIPLE OF
O
PERATION
............................................................................................................................................. 1
M
ODEL
R
EFERENCE
....................................................................................................................................................... 1
S
YMBOL
D
EFINITIONS
.................................................................................................................................................... 3
I
NTENDED
C
OUNTRY
U
SAGE
......................................................................................................................................... 4
C
ERTIFICATION AND
A
PPROVALS
................................................................................................................................... 5
R
ADIO
M
ODULE
S
PECIFICATIONS
.................................................................................................................................. 5
E
LECTRICAL
S
PECIFICATIONS
........................................................................................................................................ 5
O
PERATIONAL
C
HARACTERISTICS
................................................................................................................................. 6
EMC S
PECIFICATIONS
................................................................................................................................................... 6
E
NVIRONMENTAL
S
PECIFICATIONS
................................................................................................................................ 6
A
GENCY
C
OMPLIANCE
I
NFORMATION
............................................................................................................................ 7
FCC C
OMPLIANCE
S
TATEMENTS
.............................................................................................................................. 7
IC C
OMPLIANCE
S
TATEMENTS
................................................................................................................................... 7
R
ADIO
F
REQUENCY
(RF) S
AFETY
S
TATEMENT
(FCC & IC)
.................................................................................... 7
E
UROPEAN
R
ESTRICTIONS
........................................................................................................................................ 7
KCC S
TATEMENTS
..................................................................................................................................................... 8
ANATEL S
TATEMENTS
............................................................................................................................................. 8
E
UROPEAN
(CE) D
ECLARATION OF
C
ONFORMITY
(D
O
C)
............................................................................................ 9
E
UROPEAN
D
ECLARATION OF
C
ONFORMITY
S
TATEMENTS
...................................................................................... 9
F
OR MORE INFORMATION ABOUT THE
R&TTE D
IRECTIVE
........................................................................................ 9
COUNTRY USE CODE “A” ANTENNA OPTIONS
................................................................................................ 10
COUNTRY USE CODE “B” ANTENNA OPTIONS
................................................................................................ 11
SPECIFICATIONS
.............................................................................................................................................................. 4
ANTENNA OPTIONS ALLOWED PER COUNTRY USE CODE
.............................................................................. 10
WDRR FEATURE OVERVIEW
....................................................................................................................................... 12
FUNCTIONAL INDICATORS
.......................................................................................................................................... 12
5.1 P
OWER
LED
1%
.................................................................................................................................................................. 12
TRI-COLOR OUTPUT LEDS
.................................................................................................................................. 13
5.3
Low Battery Output LED
...................................................................................................................................................... 14
LOST RF LINK OUTPUT LED
........................................................................................................................... 14
RF L
INK
S
TRENGTH
LED
S
1#
...................................................................................................................................... 14
C
ONFIGURATION
LED
S
1!
............................................................................................................................................ 14
C
ONFIGURATION
DIP S
WITCHES
1!
............................................................................................................................. 15
RF L
INK
S
WITCH
12
...................................................................................................................................................... 15
P
OWER
S
UPPLY CONNECTIONS
........................................................................................................................... 16
NPN
OR
PNP
OUTPUT CONNECTIONS
........................................................................................................... 16
L
OW BATTERY OUTPUT CONNECTIONS
........................................................................................................... 17
L
OST
RF L
INK OUTPUT CONNECTIONS
........................................................................................................... 17
ELECTRICAL CONFIGURATIONS/CONNECTIONS
................................................................................................. 15
sensing.honeywell.com
Limitless™
WDRR Receiver
7
7.1
7.2
7.3
7.4
7.5
7.6
8
Issue 5
50063987
CONFIGURATION MODES AND OPERATIONS
....................................................................................................... 18
S
TART
-
UP OR
R
E
-
START
S
EQUENCE
M
ODE
............................................................................................................... 18
S
ET
-
UP
M
ODE
.............................................................................................................................................................. 18
P
AIRING
M
ODE
............................................................................................................................................................. 19
P
URGE
M
ODE
............................................................................................................................................................... 21
F
ACTORY
R
ESET
M
ODE
............................................................................................................................................... 21
A
BORT
M
ODE
............................................................................................................................................................... 21
ANTENNA CONSIDERATIONS/OPTIONS
.................................................................................................................. 23
8.1
O
VERVIEW OF
A
NTENNA
O
PTIONS
.............................................................................................................................. 23
8.2
O
MNI
-
DIRECTIONAL
A
NTENNA
D
ESIGN
........................................................................................................................ 24
8.3
A
NTENNA
M
OUNTING AND
C
ONSIDERATIONS
.............................................................................................................. 25
8.3.1
Antenna Mounting Location with Respect to RF Signal
............................................................................. 25
8.3.2
Outdoor Installation Warnings
......................................................................................................................... 26
8.3.3
Antenna Connection, Styles, and Mounting Options
................................................................................... 27
8.3.3.1
8.3.3.2
8.3.3.3
Antenna Connection
......................................................................................................................................................... 27
Antenna Styles and Mounting Options
.......................................................................................................................... 28
Antenna Adjustment Considerations
.............................................................................................................................. 31
8.4
E
NVIRONMENTAL
U
SAGE
/C
ONCERNS
......................................................................................................................... 32
8.4.1
Choosing an Antenna/Cable to Meet Application Exposure Conditions
.................................................. 32
8.4.2
Outdoor Antenna Installations - Lightning Concerns
................................................................................... 33
8.4.3
Lightning Arrestor
.............................................................................................................................................. 33
8.4.4
RF Interference
.................................................................................................................................................. 33
8.5
C
HOOSING AN
A
NTENNA
G
AIN
(
D
B
I
)
WITH
A
CCEPTABLE
F
ADE
-M
ARGIN
................................................................... 34
9
WDRR MOUNTING...........................................................................................................................................................
35
9.1
9.2
10
10.1
10.2
11
12
13
13.1
13.2
14
14.1
15
D
IN
R
AIL MOUNTING
:
.................................................................................................................................................... 35
T
AB MOUNTING
:
............................................................................................................................................................ 35
INSPECTION AND MAINTENANCE
......................................................................................................................... 36
WDRR I
NSPECTION AND
R
EPLACEMENT
................................................................................................................ 36
A
NTENNA
I
NSPECTION AND
R
EPLACEMENT
............................................................................................................. 36
CHOOSING A WDRR SERIES CATALOG LISTING
............................................................................................. 37
QUICK START UP & INSTALLATION
...................................................................................................................... 38
ACCESSORIES
............................................................................................................................................................. 39
A
NTENNA
O
PTIONS
.................................................................................................................................................. 39
A
NTENNA
C
ABLE AND
M
OUNTING
O
PTIONS
............................................................................................................ 40
INSTALLATION DRAWINGS
..................................................................................................................................... 40
D
RAWING
A
VAILABILITY
............................................................................................................................................ 40
TROUBLESHOOTING GUIDES
................................................................................................................................. 41
Sensing and Productivity Solutions
iii
Limitless™
WDRR Receiver
L
IST OF
F
IGURES
Issue 5
50063987
Figure 1. European Declaration of Conformity (DoC)
.................................................................................................. 9
Figure 2. Limitless™ WDRR DIN Rail Receiver with location call-out
....................................................................... 12
Figure 3. Limitless™ WDRR DIN Rail Receiver with WDRRPWRASM connected
................................................... 13
Figure 4. Limitless™ Switch Housing
........................................................................................................................ 20
Figure 5. Limitless™ WDRR Housing
........................................................................................................................ 20
Figure 6. Limitless™ Switch with Function Button Depressed
.................................................................................. 20
Figure 7. Limitless™ Switch Label Placement
........................................................................................................... 20
Figure 8. Limitless™ WDRR Operation and LED Functions Chart
............................................................................ 22
Figure 9. Radiation Pattern of an Omni-directional Antenna
..................................................................................... 25
Figure 10. Limitless™ switch to WDRR Antennas with RF Signal Line of Sight (LOS) Free From Obstacles
......... 26
Figure 11. Limitless™ switch to WDRR Antennas with RF Signal Line of Sight (LOS) Affected by
......................... 26
Figure 12. Limitless™ WDRR RP-SMA Connection, Integral
.................................................................................... 28
Figure 13. Limitless™ WDRR RP-SMA Connection, Remote
................................................................................... 28
Figure 14. Straight, Right-Angle, and Tilt-and-Swivel antennas
................................................................................ 28
Figure 15. Adhesive Mount Antenna – Step 1. Pre-clean the surface
...................................................................... 29
Figure 16. Adhesive Mount Antenna – Step 2. Peel Protection from Adhesive Strip................................................
29
Figure 17. Adhesive Mount Antenna – Step 3. Mount the Antenna...........................................................................
29
Figure 18. Mast Mount Antenna – Tighten nut on mounting bracket
...................................................................... 30
Figure 19. Mast Mount Antenna – Side View with Attachment to Pipe
.................................................................. 30
Figure 20. Magnetic Mount Base with Antenna – Mounted on Steel Surface
.......................................................... 31
Figure 21. WAN09RSP Magnetic Mount Antenna
..................................................................................................... 31
Figure 22. WAN10RSP Magnetic Mount Antenna
..................................................................................................... 31
Figure 23. Through-hole mount antenna
.................................................................................................................... 31
Figure 24. Highest RF signal when antennas are as parallel to each other as possible (parallel arrangement
shown with the Limitless™ WPMM monitor and WGLA switch)
................................................................................ 32
Figure 25. Limitless™ WDRR Mounting Clips
........................................................................................................... 35
Figure 26. Limitless™ WDRR Mounting Tabs
............................................................................................................ 35
L
IST OF
T
ABLES
Table 1 –Table of Abbreviations and Definitions
.......................................................................................................... 2
Table 2 –Table Symbol Definitions
............................................................................................................................... 3
Table 3 – North America; Country Use Code “A”
........................................................................................................ 4
Table 4 – Asia Pacific; Country Use Code “B”
............................................................................................................ 4
Table 5 – European Union; Country Use Code “B”
..................................................................................................... 4
Table 6 – Other European Countries; Country Use Code “B”
..................................................................................... 4
Table 7 – Approvals and Ratings
................................................................................................................................. 5
Table 8 – Radio Module Specifications
....................................................................................................................... 5
Table 9 – Electrical Specifications
............................................................................................................................... 5
Table 10 – Environmental Specifications
..................................................................................................................... 6
Table 11 – Country Use Code A Antenna Options
..................................................................................................... 10
Table 12 – Country Use Code B Antenna Options.....................................................................................................
11
1.
vi
sensing.honeywell.com
Limitless™
WDRR Receiver
1
1.1
DESCRIPTION
General
Issue 5
50063987
The Limitless™ Series uses the latest commercial off-the-shelf wireless technology that can be used in a wide
variety of applications. This is especially beneficial for remote monitoring applications where previous wiring
installation or wire maintenance was not physically possible or economically feasible. This document will provide
installation instructions to properly install a Limitless™ Wireless DIN Rail Receiver (WDRR), as well as a detailed
understanding of its functions.
1.2
Principle of Operation
A Limitless™ input sends an RF signal to the WDRR when the Limitless™ digital input changes state. There may
be up to 14 Limitless™ digital inputs that communicate and indicate their state to a single WDRR. A change of state
of a Limitless ™ input will cause the WDRR tri-color output LED paired to that particular input to turn red or green
depending on configuration. This will also cause the associated WDRR NPN or PNP output to change state. The
WDRR indicates low battery conditions, lost RF links, as well as other diagnostic and functional operations
described in further detail throughout this manual.
1.3
Model Reference
Sensing and Productivity Solutions
1
无线连接
京公网安备 11010802033920号
Copyright © 2005-2026 EEWORLD.com.cn, Inc. All rights reserved
电子工程世界
